移动式自动上料搅拌车使用中出现罐体停转是怎么回事？_行业资讯_自动混凝土搅拌机知识_自动混凝土搅拌机_自动混凝土搅拌车厂家

站内搜索

自动混凝土搅拌机知识

公司新闻行业资讯

热点

如何全自动搅拌车系统发出的噪音？

2021-01-15

出车--搅拌车厂家给你的说明！

2021-10-30

自动混凝土搅拌机工作需要注意哪些事项？

2021-12-10

混泥土搅拌车使用应该注意什么？

2020-11-05

关于山汽

联系人：刘老师

电话：400-879-1999

公司：山东山汽工程机械（集团）有限公司

地址：山东省莱州市206国道与308省道交叉口东南50米

移动式自动上料搅拌车使用中出现罐体停转是怎么回事？

所属分类：行业资讯发布时间：2021-07-22 来源：http://www.sqjituan.cn/ 浏览量：0

现在移动式自动上料搅拌车在大型的建筑行业必不可缺少的，我们在大路上也是可以看见的，搅拌车就算是在行驶的路上也要进行不停的旋转，若是不旋转的话，里面的混凝土可以能就会结块，当我们在一次使用的话就得先清理大块的结块了，这样对搅拌车的本身也是不作好的，但是有的时候搅拌车在出现故障的时候搅拌车的罐体突然就停止转动了，这是什么原因造成的呢？

Now the mobile automatic feeding mixer is indispensable in the large construction industry. We can also see it on the road. The mixer has to rotate continuously even on the road. If it doesn't rotate, the concrete in it will agglomerate. When we use it at one time, we have to clean up the large agglomerates, This is not good for the mixer itself, but sometimes when the mixer fails, the tank of the mixer suddenly stops rotating. What's the reason for this?

检查搅拌叶片或者是侧叶片与简体内壁间有没有大的异物，若是出现这样的情况的话就就导致搅拌车的罐体停止运转，若是有较大的异物也会导致搅拌轴停转，所以能卡存异物，就是由于搅拌叶片或侧叶片与罐内壁间隙过大造成的尤其是石子。
自动混凝土搅拌车

Check whether there is any big foreign matter between the mixing blade or side blade and the inner wall of the cylinder. If there is such a situation, it will cause the tank of the mixing truck to stop running. If there is a big foreign matter, it will also cause the mixing shaft to stop running, so the foreign matter can be stuck, which is caused by the large gap between the mixing blade or side blade and the inner wall of the tank, especially the stones.

检查电机传动皮带有没有出现松动的情况，若是搅拌罐车电机的皮带过松的话就会导致传递的动力不足，所以就会导致罐体停止运转的原因。

Check whether the motor drive belt is loose. If the motor belt of the mixing tank truck is too loose, it will lead to insufficient power transmission, so it will cause the tank to stop running.

观察有没有严重超载，若是搅拌车搅拌轴如果超过正常工作负荷，会使搅拌轴转动缓慢，若负荷过大，就会导致搅拌轴停转或者是搅拌轴弯曲，从而就会导致罐体停转的现象。

Observe whether there is serious overload. If the mixing shaft of the mixer exceeds the normal working load, it will make the mixing shaft rotate slowly. If the load is too large, it will cause the mixing shaft to stop or the mixing shaft to bend, which will cause the tank to stop.

以上就是小编给大家讲解的关于搅拌车使用中出现罐体停转的原因的相关内容，通过小编的介绍大家在使用搅拌罐车之前要进行检查哦，这样大家在工作的时候才会减少故障的发生，还有就是大家在在装混凝土的时候不要一味选择多装哦，我们要学会适可而止才可以哦，以免出现负荷的现象，这样就会损坏搅拌车的哦，从而也会降低搅拌车的使用寿命。

The above is what Xiaobian explained to you about the causes of the tank stalling in the use of the mixer. Through Xiaobian's introduction, you should check before using the mixer, so that you can reduce the occurrence of faults when you work. In addition, you should not blindly choose to load more concrete, We should learn to stop just enough, so as to avoid the phenomenon of load, which will damage the performance of the mixer and reduce the service life of the mixer.

上一页：混凝土车载4G视频监控的作用有哪些？下一页：自上料搅拌车如何确定给水量？

热门产品 / HOT PRODUCT