混凝土搅拌机简称搅拌车,是用来运送建筑用混凝土的专用车辆,在混凝土的运输过程中,搅拌机的搅拌罐会一直保持匀速转动,这样既可以让混凝土搅拌的更加均匀,又可以防止混凝土凝固。搅拌车行驶的动力来自发动机,发动机带动驱动装置让搅拌车行驶起来,所以说搅拌机的驱动装置也是非常重要的。
The concrete mixer, abbreviated as mixer truck, is a special vehicle used to transport concrete for construction. During the transportation of concrete, the mixing tank of the mixer will always rotate at a constant speed, which can not only make the concrete mix more evenly, but also prevent the concrete from setting. The driving power of the mixer truck comes from the engine, which drives the driving device to drive the mixer truck, so the driving device of the mixer is also very important.
搅拌车的驱动装置也是需要保养的,它的保养需要做到以下几点:
The driving device of the mixer truck also needs maintenance, and its maintenance needs to do the following:
万向转动部分是故障多发部位,要按时加注润滑脂,并要经常检查磨损情况,及时修理更换,搅拌机的车队一般都有备用的万向轴,以保证一旦发生故障就能在几十分钟内恢复工作。
The universal joint rotating part is a fault prone part. It is necessary to fill the lubricating grease on time, regularly check the wear condition, and repair and replace it in time. Generally, the mixer fleet has a spare universal joint shaft, so as to ensure that the work can be restored within dozens of minutes in case of a fault.
2. 保证液压油的清洁,混凝土搅拌车的作业环境一般都比较差,因此一定要防止污水泥沙进入液压系统。液压油要按照使用手册要求定期的进行更换,平时如果发现液压油中混入水或者泥沙,一定要立即停机清洗液压系统、更换液压油。
2. ensure that the hydraulic oil is clean. Generally, the working environment of the concrete mixer is poor. Therefore, it is necessary to prevent the dirty cement sand from entering the hydraulic system. The hydraulic oil shall be replaced regularly according to the requirements of the manual. If water or sediment is found in the hydraulic oil at ordinary times, it must be shut down immediately to clean the hydraulic system and replace the hydraulic oil.
3. 要保证液压油冷却装置有效,要定时清理液压油散热器,避免散热器被水泥堵塞,检查散热器电动风扇运转是否正常,防止液压油温度超标。液压部分只要保证液压油清洁,一般故障不会多,不同的液压系统的使用寿命也不相同。
3. ensure that the hydraulic oil cooling device is effective, clean the hydraulic oil radiator regularly to avoid the radiator being blocked by cement, and check whether the electric fan of the radiator operates normally to prevent the hydraulic oil temperature from exceeding the standard. As long as the hydraulic part keeps the hydraulic oil clean, there will not be many common faults, and the service life of different hydraulic systems will be different.
The wonderful content of this article is provided by the knowledge of automatic concrete mixer. There are many wonderful content on this website. You can click to enter more content http://www.sqjituan.cn We have special customer service to answer your questions