混凝土强度不够与搅拌车有关吗？_常见问题_自动混凝土搅拌机_自动混凝土搅拌车厂家

站内搜索

常见问题

热点

全自动搅拌车怎样操作才能省油？

2020-07-22

混凝土搅拌机干燥罐使用多久该更换？

2020-12-28

混凝土搅拌车怎么保养省油？

2021-11-17

自动混凝土搅拌车损坏后的维修对策

2021-09-03

关于山汽

联系人：刘老师

电话：400-879-1999

公司：山东山汽工程机械（集团）有限公司

地址：山东省莱州市206国道与308省道交叉口东南50米

混凝土强度不够与搅拌车有关吗？

所属分类：常见问题发布时间：2021-09-19 来源：http://www.sqjituan.cn/ 浏览量：0

混凝土强度不足造成的后果是混凝土抗渗性能降低，耐久性降低，构件出现裂缝和变形，承载能力下降，严重者会影响到建筑物正常使用甚造成事故。鉴于混凝土强度不足造成的危害，弄清混凝土造成混凝土强度不足的原因及其采取何种措施进行控制是非常必要的。造成混凝土强度不足的常见原因有两个方面：

The consequence of insufficient concrete strength is the reduction of concrete impermeability, durability, cracks and deformation of components, and the decline of bearing capacity. In serious cases, it will affect the normal use of buildings and even cause accidents. In view of the harm caused by insufficient concrete strength, it is very necessary to clarify the causes of insufficient concrete strength and what measures should be taken to control it. There are two common reasons for insufficient concrete strength:
自动混凝土搅拌车

水泥质量不好是造成混凝土强度不足的关键因素。

The poor quality of cement is the key factor causing the insufficient strength of concrete.

石子石子质量不好包括石子强度低、体积稳定性差、石子形状与表面状态。

The poor quality of stones includes low strength, poor volume stability, shape and surface state of stones.

在混凝土试块试压时，有时会发现石子被压碎了，这说明石子强度低于混凝土的强度，导致混凝土实际强度下降。有些由于多孔燧石、页岩、带有膨胀粘土的石灰岩等制成的碎石子，在干湿交替或冻融循环作用下，常表现为体积稳定性差，而导致混凝土强度降低。针片状石子含量高影响混凝土强度。石子表面光滑则无法与水泥砂浆结合好，也会影响混凝土强度。

During the pressure test of concrete test block, it is sometimes found that the stone is crushed, which shows that the strength of stone is lower than that of concrete, resulting in the decrease of actual strength of concrete. Some crushed stones made of porous chert, shale and limestone with expansive clay often show poor volume stability under the action of dry wet alternation or freeze-thaw cycle, resulting in the reduction of concrete strength. The high content of needle flake stone affects the strength of concrete. If the stone surface is smooth, it cannot be combined with cement mortar, and it will also affect the strength of concrete.

砂子配制混凝土用砂子的粗细程度按细度模数分为粗、中、细3个等级，配制混凝土宜优先选用中砂。

The thickness of sand for concrete preparation is divided into three grades: coarse, medium and fine according to the fineness modulus. Medium sand should be preferred for concrete preparation.

砂子质量的好坏可用细度模数、含泥量、泥块含量等几项指标来评定。其中含泥量、泥块含量对混凝土强度影响。这是因为泥块遇水会呈现浆状，胶结在一颗或数颗砂子表面，在混凝土中与水泥起着隔离作用，从而影响了水泥与石子的粘结力。

The quality of sand can be evaluated by fineness modulus, mud content, mud block content and other indicators. Among them, mud content and mud block content have an impact on concrete strength. This is because the mud block will appear slurry when encountering water, which is cemented on the surface of one or several sands and plays an isolation role with cement in the concrete, thus affecting the adhesion between cement and stone.

上一页：混凝土自动上料搅拌车中冷增压发动机的作用下一页：小型混凝土搅拌泵车选择我们要看哪些？

热门产品 / HOT PRODUCT