山汽教你自动上料搅拌一体车怎么用_常见问题_自动混凝土搅拌机_自动混凝土搅拌车厂家

站内搜索

常见问题

热点

自上料搅拌机会发生侧翻的机率？

2022-04-22

自动混凝土搅拌机回收哪些方面的影响？

2021-02-22

为什么说选自动上料搅拌车不能只盯钱看？

2022-11-10

自动混凝土搅拌车清理残渣的办法

2021-12-22

关于山汽

联系人：刘老师

电话：400-879-1999

公司：山东山汽工程机械（集团）有限公司

地址：山东省莱州市206国道与308省道交叉口东南50米

山汽教你自动上料搅拌一体车怎么用

所属分类：常见问题发布时间：2021-12-02 来源：http://www.sqjituan.cn/ 浏览量：0

一、启动前应对机械系统各部位认真进行检查，确认良好后方可启动。

1、 Before starting, all parts of the mechanical system shall be carefully inspected and can be started only after they are confirmed to be good.

二、启动前，应将搅拌操纵杆放在“空档”位置。

2、 Before starting, put the mixing control lever in the "neutral" position.

三、启动后，应将搅拌操纵杆放在“卸料”位置，放去筒内积水。

3、 After startup, put the mixing control lever at the "unloading" position to remove the accumulated water in the cylinder.

四、装料时，搅拌操作杆应放在“装料”位置。

4、 When loading, the mixing operating lever shall be placed at the "loading" position.

五、运输前，卸料槽要固定在“行驶”位置，防止摆动。

5、 Before transportation, the discharge chute shall be fixed in the "driving" position to prevent swing.

六、操作操纵杆时，应在“空档”位置稍作停留后方可动下一个位置。

6、 When operating the control lever, stay in the "neutral" position for a while before moving to the next position.

七、搞好文明施工，桶内多余材料不准随便乱倒。卸料后对搅拌筒、料槽、托辊等部位进行清洗。

7、 Do a good job in civilized construction, and the excess materials in the bucket are not allowed to be dumped randomly. After unloading, clean the mixing drum, chute, idler and other parts.

八、人进入筒内清砼结块时，应将车辆熄火，拔下电门钥匙，筒外设人监护。

8、 When a person enters the barrel to clear the concrete caking, the vehicle shall be turned off, the switch key shall be removed, and a person shall be arranged outside the barrel for supervision.

搅拌车是一种特殊车辆，并不是所有会开车的司机都会开搅拌车，如果操作不当会引起翻车、液压泵、马达、减速机过快磨损甚出现严重后果。

Mixer truck is a special vehicle. Not all drivers who can drive will drive the mixer truck. Improper operation will cause rollover, excessive wear of hydraulic pump, motor and reducer, and even serious consequences.

.起动搅拌车之前，应把搅拌筒操作手柄放在“停止”位置。

Before starting the mixer truck, put the operating handle of the mixing drum at the "stop" position.

.搅拌车起动发动机后，应使搅拌筒在低速下转动10分钟左右，使液压油温升到20以上后方可工作。

After starting the engine of the mixer truck, make the mixing drum rotate at low speed for about 10 minutes to make the hydraulic oil temperature rise to more than 20 before operation.

.搅拌车在露天停放时，装料前应将搅拌筒反转，将积水和杂物排出，以保证混凝土的质量。

When the mixer truck is parked in the open air, the mixing drum shall be reversed before loading to discharge ponding and sundries, so as to ensure the quality of concrete.

.搅拌车在运输混凝土时，要保证滑斗放置牢固，防止因松动造成摆动，在行进中打伤行人或影响其它车辆正常运行。

When transporting concrete, the mixer shall ensure that the sliding bucket is firmly placed to prevent swinging due to looseness, injuring pedestrians or affecting the normal operation of other vehicles.

搅拌车装运搅拌好的混凝土时，搅拌筒转速为2-10转/分，在运输过程中，平坦路面上搅拌筒转速保证在2-3转/分，行驶在侧倾坡度大于50的路面，或左右晃动较大的路面时，应停止搅拌旋转，待路况好转后再恢复搅拌旋转。

When the mixer truck transports the mixed concrete, the rotating speed of the mixing drum is 2-10 R / min. during transportation, the rotating speed of the mixing drum on the flat road is guaranteed to be 2-3 R / min. when driving on the road with a side slope greater than 50 or the road with large shaking left and right, the mixing and rotation shall be stopped and resumed after the road conditions improve.

混凝土搅拌车运送混凝土的时间不能超过搅拌站规定的时间。运送混凝土途中，搅拌筒不得长时间停转，以防混凝土产生离析现象。司机应时常观察混凝土情况，发现异常及时通报调度室，申请做出处理。

The time for concrete transportation by concrete mixer truck shall not exceed the time specified in the mixing plant. During the transportation of concrete, the mixing drum shall not stop for a long time to prevent segregation of concrete. The driver shall always observe the concrete condition, timely report any abnormality to the dispatching room and apply for handling.

搅拌车车内装有混凝土时，在现场停滞时间不得超过1小时，如超时应立即要求现场负责人给予及时处理。

When the mixer truck is loaded with concrete, the standstill time on the site shall not exceed 1 hour. In case of overtime, the person in charge of the site shall be required to deal with it in time.

搅拌车运送混凝土塌落度不得低于8cm。从混凝土入罐到排出，气温高时不得超过2小时排出，阴雨天气温度低时，不得超过2.5小时。

The slump of concrete transported by mixer truck shall not be less than 8cm. The concrete shall not be discharged for more than 2 hours when the temperature is high and 2.5 hours when the temperature is low in cloudy and rainy weather.

搅拌车在排出混凝土之前，应使搅拌筒在10-12转/分的转速下转动1分钟，再进行排料。

Before discharging concrete, the mixer shall rotate the mixing drum at the speed of 10-12 rpm for 1 minute before discharging.

混凝土搅拌车出料完毕，应立即用随车的软管放水将进料口、出料斗及出料溜槽等部位冲洗干净，排去粘结在车身各处的污物及残留混凝土，再向搅拌筒内注水150-200L的清水，在返回途中要让搅拌筒慢速转动，以清洗内壁，避免残余料渣附在筒壁和搅拌叶上，并在再一次装料前将这些水放掉。

After the discharge of the concrete mixer truck, the feeding inlet, discharge hopper and discharge chute shall be washed immediately with the hose attached to the truck, the dirt and residual concrete bonded to the vehicle body shall be discharged, and then 150-200l of clean water shall be injected into the mixing drum. On the way back, the mixing drum shall rotate slowly to clean the inner wall and avoid residual slag attached to the drum wall and mixing blade, And drain the water before loading again.

混凝土搅拌车运送混凝土时，发动机转速在1000-1400转/分范围内工作，以使发动机有大的扭距，在运送混凝土过程中，车速不得超过40km/h，以避免危险发生。

When the concrete mixer truck is transporting concrete, the engine speed shall work within the range of 1000-1400 rpm to make the engine have large torque. During the transportation of concrete, the speed shall not exceed 40km / h to avoid danger.

搅拌车工作完毕，应把搅拌筒内部和车身清洗干净，不能使剩余的混凝土留在筒内。

After the mixer truck is completed, the interior and body of the mixing drum shall be cleaned, and the remaining concrete shall not be left in the drum.

搅拌车在水泵工作时，禁止空转，连续使用时不要超过15分钟。

When the water pump of the mixer truck is working, it is forbidden to idle, and the continuous use shall not exceed 15 minutes.

混凝土搅拌车水箱的水量要经常保持装满，以备急用，冬季停机后，应将水箱、水泵、水管、搅拌筒内的水放净，并停放在朝阳、不积水的地方，以免冻坏机械。

The water volume of the water tank of the concrete mixer truck shall be always kept full for emergency use. After shutdown in winter, the water in the water tank, water pump, water pipe and mixing drum shall be drained and parked in a place where there is no ponding in the sun to avoid freezing the machine.

搅拌车在冬季应及时安装保温套，并使用防冻液对搅拌车加以保护，根据天气变化更换燃油标号，确保机械的正常使用。

In winter, the mixer shall be timely installed with thermal insulation sleeve, protected with antifreeze, and the fuel grade shall be changed according to the weather change to ensure the normal use of the machinery.

在检查、修理搅拌车液压传动部分时，应使发动机和液压泵在没有压力的情况下进行。

When checking and repairing the hydraulic transmission part of the mixer truck, the engine and hydraulic pump shall be operated without pressure.

在调整混凝土搅拌车各部间隙、行程、压力时，应由专职人员检查同意；更换机件时，要由部长或主管经理签字，否则出现问题后追究有关人员责任。

When adjusting the clearance, stroke and pressure of each part of the concrete mixer, the full-time personnel shall check and agree; When replacing parts, the director or manager in charge shall sign, otherwise relevant personnel shall be investigated for responsibility in case of problems.

上一页：全自动搅拌车的使用维护保养要点有哪些？下一页：自上料搅拌车刹车小知识

热门产品 / HOT PRODUCT