自动上料混凝土搅拌车密封胶条的日常维护!_公司新闻_自动混凝土搅拌机知识_自动混凝土搅拌机_自动混凝土搅拌车厂家

站内搜索

自动混凝土搅拌机知识

公司新闻行业资讯

热点

自动上料搅拌车的四大功能

2022-05-18

夏季如何防止混凝土搅拌车全自动搅拌车过热？

2021-06-15

降低自动搅拌车零件磨损需注意的问题！

2021-02-06

搅拌机一体机的倒车误区有哪些？

2022-09-02

关于山汽

联系人：刘老师

电话：400-879-1999

公司：山东山汽工程机械（集团）有限公司

地址：山东省莱州市206国道与308省道交叉口东南50米

自动上料混凝土搅拌车密封胶条的日常维护!

所属分类：公司新闻发布时间：2020-10-08 来源：http://www.sqjituan.cn/ 浏览量：0

1、检查混凝土搅拌车密封条有无大的裂纹，有无断裂。如果密封条断裂了，可以使用粘结剂进行修补。特别是使用密封条专用粘结剂，很容易就能把大的裂纹条补好。当然，如果密封条损伤严重，或老化程度较大，还是更换新密封条省事。

1. Check whether the sealing strip of concrete mixer truck has large cracks and cracks. If the seal is broken, it can be repaired with adhesive. Especially using special adhesive for sealing strip, it is easy to mend the big crack strip. Of course, if the seal is seriously damaged or aged, it is better to replace the new seal.

2、司机在使用混凝土搅拌车洗涤剂进行清洗门窗密封胶条之后，涂覆一层高渗透性的保护剂，这样既能防止密封条老化又能极大地提高密封条的密封性。除此之外，密封条的缝隙之间很容易塞满沙尘，从而引发锈蚀。为此，应该用刷子把沙尘等干净。

2. After cleaning the sealant strip of doors and windows with concrete mixer detergent, it is better to apply a layer of protective agent with high permeability, which can not only prevent the sealing strip from aging, but also greatly improve the sealing performance of the sealing strip. In addition, the gap between the sealing strip is easy to be filled with sand and dust, causing corrosion. Therefore, the dust should be removed with a brush.
自动混凝土搅拌车

3、在更换整个车身时，应在焊缝的搭接部分涂一层密封胶，胶层厚度应约为1mm，并且胶层不得有虚粘、气泡等缺陷。在整个地板下表面和前轮罩下表面应涂3mm-4mm的弹性涂层及防腐涂层。这些措施不仅可以大大增强整车的密封性和减慢车身的锈蚀速度，而且还可以大大提高乘坐舒适性。

3. When replacing the whole car body, a layer of sealant should be applied to the lap joint of the welding seam. The thickness of the adhesive layer should be about 1 mm, and the adhesive layer should not have defects such as virtual adhesion and bubbles. 3 MM-4 mm elastic coating and anti-corrosion coating shall be applied on the whole underfloor surface and the lower surface of front wheel housing. These measures can not only greatly enhance the sealing of the vehicle and slow down the corrosion speed of the body, but also greatly improve the riding comfort.

4、车门与车身的密封是一个比较困难的部位，密封要求比较严，应密封的部分比较长，各密封部位的断面形状不尽相同，而且车门启闭频繁。在混凝土搅拌车上常设置3道,4道密封，安装前支柱及车顶侧横梁部位的四重密封的构造。这种多道密封一般都布置在前门缝里，除具有密封功能外，还有汽车隔音降噪的作用。

4. The sealing between the door and the body is a difficult part. The sealing requirements are relatively strict. The parts that should be sealed are relatively long. The section shape of each sealing part is not the same, and the door is opened and closed frequently. In the concrete mixer truck, three or four seals are often set up, and the four seal structure of the front pillar and roof side beam is installed. This kind of multi-channel seal is generally arranged in the front door seam. In addition to the sealing function, it also has the function of sound insulation and noise reduction.

5、在车窗玻璃损坏后，司机在换用玻璃时，要检查密封条有无损伤。由于车窗经过修理后往往回复不到原来的形状，因此，这时除了要保证能轻松拉动或升降车窗玻璃外，还要注意车窗玻璃四周的密封性。如果玻璃同玻璃槽口的缝隙不均，橡胶条与玻璃、玻璃槽接触不良，司机可以用手能轻易地将密封条拉脱。

5. After the window glass is damaged, the driver should check whether the sealing strip is damaged when changing the glass. As the window after repair often can not return to the original shape, so at this time, in addition to ensuring easy pulling or lifting the window glass, but also pay attention to the sealing around the window glass. If the gap between the glass and the glass slot is uneven, and the rubber strip is not in good contact with the glass and glass groove, the driver can easily pull off the sealing strip by hand.

6、司机在换车顶时，应先在车顶周边压合处涂一层导电密封胶，待焊好后再在流水槽内及接缝处遍涂折边胶，这不但有助于车身的密封，更可防止车身因翻边焊缝处积水而产生早期锈蚀。

6. When changing the roof, the driver should first apply a layer of conductive sealant at the pressing joint around the roof, and then apply the folding adhesive in the water channel and the joint after welding. This not only helps to seal the body, but also prevents the body from early corrosion due to water accumulation at the flanging weld.

7、混凝土搅拌车天窗是大多数家用轿车的基本配置。当汽车天窗打开时，橡胶密封条轨道暴露在空气中，难免堆积粉尘，甚跑进小沙砾。长时间使用可能导致天窗因磨损而变形，并堵塞排水孔。所以定期清理轨道，为轨道涂抹润滑油十分重要。

7. The skylight of concrete mixer truck is the basic configuration of most family cars. When the car skylight is opened, the rubber sealing strip track is exposed to the air, which inevitably accumulates dust and even runs into small gravel. Prolonged use may cause the skylight to deform due to wear and block the drain hole. Therefore, it is very important to clean the track regularly and apply lubricating oil to the track.

有了自动混凝土搅拌车上面的小总结，希望对广大客户有所帮助，如果有什么不理解的或者寻求帮助的请点击我们的网站：http://www.sqjituan.cn或者来电咨询，我们会尽全力为您

With the summary of the automatic concrete mixer, I hope it can help our customers. If you have any questions or ask for help, please click our website: http://www.sqjituan.cn Or call consultation, we will try our best to solve it for you

上一页：混凝土搅拌车每日使用检查下一页：正确操作混凝土搅拌车这些情况要熟知！

热门产品 / HOT PRODUCT